Level 1 sweep and inspection to the NFPA 211 annual standard - flue, crown, cap, and flashing checked and photographed
Chimney sweep logs do not sweep chimneys. They loosen some creosote - which then falls where a brush and vacuum still have to collect it.
Before
After
Before
After
Before
AfterFast, Reliable Chimney Cap & Crown Across Whitehall Township
A chimney cap and crown repair in Whitehall Township typically runs $425-$1,850 depending on whether you need a simple cap replacement or a full crown rebuild with drip edge. Most jobs in the township are completed within 5-7 business days of the written estimate. We know this area’s chimneys better than most because we’ve been documenting them with cameras since 2009, and the housing stock here tells a very specific story. Call (980) 580-8641 for a written price on your chimney cap or crown, no inspection games.
Whitehall Township homes were built in a burst between the 1950s and early 1970s, which means most chimneys here share the same age, the same clay-tile flues, and the same slow failure pattern. We schedule around Lehigh Valley weather, show up with named techs and a text when we’re on the way, and leave you with photos of everything we found and fixed.
Why Emberly Chimney Cleaners Is Whitehall Township’s Preferred Chimney Cap & Crown Company
We run background-checked, uniformed crews through Whitehall Township week in and week out. Homeowners near the Whitehall-Coplay School District and along MacArthur Road call us for the same reason: they want a camera down the flue before anyone quotes a liner, a crown, or a cap. Clause 4 of the Haven Standard has required a documented photo record on every job since 2009, long before regulated or insured. That means when we quote a crown rebuild on a 1962 ranch in Hokendauqua, you see the spalled mortar in the photo before you spend a dollar.
We answer the phone with a live person 24/7, not a voicemail. Scheduling from our Philadelphia office means crews are dispatched to Whitehall Township with local route knowledge, and every job is quoted in writing before work starts, per Clause 1 of the Haven Standard. Corrine Halstead runs the operation with a single rule: nothing is recommended without camera evidence the homeowner can see. That standard matters in Whitehall Township specifically, because the chimneys here fail in predictable ways that bad actors exploit for five-figure upsells.
We offer a Free Second Opinion on any written estimate. Bring us a competitor’s quote from an Allentown or Bethlehem company and we’ll show you, camera in hand, what’s actually needed versus what’s been padded. That’s the 365-Day Done Right Promise working: if it’s not done right, we make it right. No asterisks, no countdown codes, no urgency theatre.
Our Chimney Cap & Crown Services in Whitehall Township
We don’t sell caps and crowns the way a supply house sells parts. We sell the outcome: water stays out, the flue stays dry, gas exhausts where it should, and birds stop nesting in the dead coal flue your split-level still has. These are the services we run most often across Whitehall Township.
Cap Installation
A new chimney cap for a single-flue gas or wood chimney in Whitehall Township runs $185-$475 installed, depending on the flue dimensions and whether we’re matching an existing cap profile. Most 1950s-70s homes here either have no cap at all or a rusted Famco cap that’s been on the stack since the Carter administration. We install stainless caps with a cage screen, and we size them to the actual flue, not the brick opening. In Cementon especially, we find flue tiles that were never round, never standard, and never sealed, so the cap has to be measured in person, not pulled off a truck shelf.
Cap Replacement
When a cap is rusted, blown off by a Lehigh Valley nor’easter, or chewed open by raccoons, replacement is the easy fix. But in Whitehall Township, replacement often reveals a second problem: the crown underneath is crumbling, which is why the cap failed in the first place. We don’t replace a cap without camera-scanning the flue and the crown condition, and we quote both together if needed. A typical cap replacement with crown correction runs $600-$1,200 here.
Crown Repair
Crown repair is the single most-needed chimney service in Whitehall Township, and it’s the one that gets ignored until water streaks appear on the ceiling below. A crown is the concrete slab at the top of the chimney that sheds rain away from the flue. On 1950s-70s brick chimneys here, crowns were poured too thin, with no drip edge, and the freeze-thaw cycles that rip through the Lehigh Valley every winter have spalled them down to the brick course. Crown repair runs $425-$950 depending on how much of the old crown has to be chipped out and re-poured. We always install a drip edge, because a crown without one isn’t a crown, it’s a sponge.
Crown Coating
For crowns that are still structurally sound but showing hairline cracks and surface spalling, a crown coating can buy years of life for $350-$600. We use a flexible waterproof membrane that bridges the hairline cracks and moves with the freeze-thaw expansion, which is exactly what Whitehall Township’s winter cycles demand. But we won’t coat a crown that’s already lost its pitch or is shedding pieces of aggregate. Coating over a failed crown is how you end up paying twice. We’ll show you the camera footage and tell you straight: coat it or re-pour it. Your call, based on evidence.
What happens when you call
- 1
A real person answersNo phone trees - you reach a local pro.
- 2
You get an upfront price rangeHonest numbers before anyone is dispatched.
- 3
A background-checked tech heads outLicensed & insured, dispatched right away.
- 4
You approve before work beginsNothing starts until you say go.
BeforeAfterTrusted Brands We Service in Whitehall Township
We stock and install caps and crown materials from Olympia Chimney, Famco, and Gelco, sourced through the Haven buying network to keep Whitehall Township pricing honest. Olympia Chimney multi-flue caps are our default for Cementon’s coal-era stacks because they can be fabricated to cover two, three, or four flues at once while leaving the dead chamber vented and screened. Famco single-flue caps go on most of the ranch homes along the MacArthur Road corridor. Gelco coatings are on every crown repair truck that leaves our Philadelphia dispatch for Whitehall Township. If you’ve got a brand-specific part already quoted by another company, bring it in. We’ll price against it line by line.
Common Chimney Cap & Crown Problems We See in Whitehall Township Homes
- Clay-tile flue liners cracking from freeze-thaw cycles. The Lehigh Valley cycles above and below freezing dozens of times each winter, and Whitehall Township’s 1950s-70s clay tiles absorb water, freeze, and crack. Cracks behind the crown let water and creosote bleed into the masonry, which is why a crown that looks fine from the ground is often failing at the flue line.
- Low-pitch roofs trapping water at the chimney base. Most ranch and split-level homes here have low-pitch or near-flat roof sections near the chimney. Water pools at the base, wicks into the brick, and freezes, spalling the mortar joints until the crown starts shedding brick into gutters. We see this every winter in the neighborhoods off Eberhart Road.
- Open or abandoned coal flues in Cementon. Many Cementon worker cottages were built with multi-flue stacks serving coal furnaces and coal cookstoves at the same time. When gas came in the 1960s, one flue was lined or capped, but the other was often left open. We regularly find birds, rain, and third-degree creosote glaze in a chamber nobody has inspected in fifty years.
- Undersized flues stuffed with modern wood stove pipe. Whitehall Township’s original clay-tile flues were sized for a coal-to-gas transition, not modern wood-burning. A new homeowner buys a wood stove, connects it to a flue that’s too small or the wrong shape, and ends up with a draft problem no cap can fix. We correct the crown, the cap, and sometimes the liner, but we’ll show you the camera footage before any of it happens.
In the Cementon section, our techs found a split-level with a corroded single-flue cap and a crown spalled down to the brick course. Water had been pouring into the flue and pooling at the smoke chamber. We pulled the rusted Famco cap, rebuilt the crown with a proper drip edge, and installed an Olympia Chimney multi-flue cap sized for the active gas flue and the abandoned coal-era chamber, then ran a camera down to show the homeowner the now-dry, guarded liner. That’s the difference between a cap quote and a chimney correction.
Pricing for Chimney Cap & Crown in Whitehall Township, PA
Here’s what Whitehall Township homeowners should expect to pay, in real numbers, not a call-for-pricing shell game:
- Single-flue cap installation: $185-$475
- Multi-flue or custom cap (Cementon coal stacks, oversized flues): $650-$1,400
- Crown repair with drip edge: $425-$950
- Full crown rebuild (when the old crown is gone): $800-$1,850
- Crown coating (for sound crowns with hairline cracks): $350-$600
What moves the price is flue count, crown condition, roof access, and whether the existing cap can be reused or needs custom fabrication. We write all of this down before work starts. No “it depends” without numbers attached. No surprise invoice at the end. Call (980) 580-8641 for a written estimate, free of charge, backed by camera evidence.
We Also Serve Cities Near Whitehall Township
Our crews cover the Lehigh Valley and beyond, including Whitehall Township, Allentown, Bethlehem, Philadelphia, and Pittsburgh. If you’re in a neighboring town and need a Chimney Cap & Crown inspection with camera documentation, we can route a crew from our Philadelphia office to you, often within a few days.
Serving Whitehall Township, PA - Our Local Coverage Area
We’re based in the Whitehall Township area and know this community well. Use the map below to see our service coverage - if you’re nearby, we can almost certainly help.
FAQs - Chimney Cap & Crown in Whitehall Township
Because the builders who put up Whitehall Township’s post-war housing stock were working fast, cheap, and to a coal-era standard that didn’t require caps or drip edges. A 1964 split-level off MacArthur Road likely got a thin concrete crown with no overhang and no cap at all. The freeze-thaw cycles of the Lehigh Valley have since turned those crowns into mush. The fix is a re-poured crown with a real drip edge and a stainless cap sized to the flue, and we’ll show you the camera footage before we touch a trowel. Call (980) 580-8641 for a written quote.
You can’t, from the ground, and that’s the point. An open coal flue looks like a shadowed brick opening from the sidewalk. The only way to know is a camera scan down the flue, which is exactly what Clause 4 of the Haven Standard requires on every visit. In Cementon’s converted worker cottages, we routinely find a gas appliance venting into one flue while the dead coal flue next to it is open to birds, rain, and whatever else wants in. We cap the dead flue and screen the active one, but first we show you the footage. Call (980) 580-8641 and we’ll schedule the camera.
It depends on whether the crown is structurally intact or already crumbling. A crown with hairline cracks and surface spalling but good pitch and aggregate can be coated with a Gelco flexible membrane for $350-$600 and run for years. A crown that’s shed brick into the gutters or has a visible gap at the flue line needs full repair, which runs $425-$950. We don’t guess and we don’t upsell. The camera tells us which one you need, and the written quote tells you what it costs before work starts. Call (980) 580-8641 for a free estimate.
A custom cap has to cover two flues that were never the same size, while leaving the dead coal chamber vented and screened so it can dry out. That’s not a stock part. We fabricate multi-flue caps from Olympia Chimney to measure the exact flue layout on your stack, whether it’s in Cementon, Hokendauqua, or anywhere else in Whitehall Township. The alternative is squeezing an off-the-shelf cap onto a brick opening it doesn’t match, which leaks at the first hard rain. Custom fabrication runs $650-$1,400, and it’s the only right answer for a coal-era stack. Call (980) 580-8641 for a written price.
It will stop most of the water that enters from above, which is the water that spalls brick, rusts dampers, and pools at the smoke shelf. But a crown repair alone won’t fix a clay-tile liner that’s already cracked from decades of Lehigh Valley freeze-thaw cycles. In Whitehall Township, we often find both problems: a failed crown letting water in and a cracked tile liner letting it bleed into the masonry. We’ll show you both on camera, then quote the crown first and the liner only if it’s actually needed. No liner upsell, no crown upsell, no pressure. Call (980) 580-8641 and we’ll walk you through what the camera sees.
Written by Corrine Halstead, Owner at Emberly Chimney Cleaners, serving Whitehall Township under the Haven Standard since 2009.